Publications by authors named "Kamal Mjoun"

2 Publications

  • Page 1 of 1

Extruded aquafeeds containing distillers dried grains with solubles: effects on extrudate properties and processing behaviour.

J Sci Food Agric 2011 Dec 1;91(15):2865-74. Epub 2011 Jul 1.

USDA-ARS, North Central Agricultural Research Laboratory, 2923 Medary Avenue, Brookings, SD 57006, USA.

Background: The tremendous supply and low cost of distillers dried grains with solubles (DDGS) make it an attractive feedstuff for aquaculture diets. Also, several studies have shown that DDGS can be successfully fed to various finfish. The objective of this study was to evaluate the effects of inclusion rate of DDGS (0, 250, 500 g kg(-1) ), feed moisture content (350, 450 g kg(-1) ) and die opening area (die A = 18.85 mm(2) , die B = 3988.45 mm(2) ) on the properties of the extrudates and on processing behaviour using a single-screw extruder.

Results: Increasing the inclusion rate of DDGS resulted in extrudates with lower unit density, bulk density, expansion ratio, water solubility index and brightness (Hunter L) but higher redness (Hunter a) and yellowness (Hunter b). The increase in moisture content affected the extrudate properties in different ways: it increased bulk density, Hunter L, Hunter b and mass flow rate, whereas specific mechanical energy decreased at high moisture content. Increasing the die opening area primarily decreased expansion ratio of extrudates, power consumption and barrel temperatures but increased mass flow rate.

Conclusion: Extrudates from all treatments exhibited high durability and floatability, and less energy was required to produce extrudates when DDGS was used compared with soybean meal-based diets. The aquaculture industry can use this information to develop high-quality feeds at low cost.
View Article and Find Full Text PDF

Download full-text PDF

Source
http://dx.doi.org/10.1002/jsfa.4536DOI Listing
December 2011

Fermentation characteristics and aerobic stability of wet corn distillers grains with solubles ensiled in combination with whole plant corn.

J Sci Food Agric 2011 May 18;91(7):1336-40. Epub 2011 Feb 18.

Dairy Science Department, South Dakota State University, Brookings, SD 57007, USA.

Background: Wet corn distillers grains with solubles (WDG) are prone to aerobic spoilage when stored for an extended period of time. The objective of this study was to evaluate the fermentation characteristics of ensiling WDG with whole plant corn (WPC) using the following combinations: (1) 100% WPC; (2) 75% WPC + 25% WDG; (3) 50% WPC + 50% WDG; and (4) 100% WDG.

Results: The initial pH was greatest for 100% WPC and lowest for 100% WDG (5.7, 4.6, 4.0, and 3.1, respectively). Concentrations of ammonia nitrogen (12.0, 26.8, 40.7, and 50.8 g kg(-1) dry matter (DM)) and Crude protein (CP) (98.7, 155.8, 206.8, and 307.9 g kg(-1) of DM) increased with increasing concentrations of WDG. Lactic acid concentration prior to ensiling was greatest for 100% WDG (9.0 g kg(-1) DM) and decreased with WPC in the silage. Acetic, propionic, and butyric acids were not present prior to ensiling. The pH of the ensiled feeds dropped below 4.0 by day 3, with no further decrease over time. Acetic acid increased from undetected amounts at day 0 to 38.8, 43.9, 43.2, and 2.2 g kg(-1) of DM at day 129 as concentration of WDG increased. Aerobic stability was enhanced with increasing WDG concentration in the silage.

Conclusion: Fermentation, nutrient profile, and aerobic stability can be improved when ensiling wet distillers grains with whole plant corn.
View Article and Find Full Text PDF

Download full-text PDF

Source
http://dx.doi.org/10.1002/jsfa.4323DOI Listing
May 2011